Vulcan-hart C24EA3 480V BASIC User Manual download pdf (Page 12)

MODEL C24EA - DRAIN BOX

F25213 (May 2006) Page 12 of 52

CLOSE-UP FROM RIGHT SIDE OF STEAMER

Adjustment

1. Reinstall striker with slot pointing upward and

hand tighten nut only.

2. Close door to center striker in front panel

mounting hole.

3. Open door and check striker slot for horizontal

alignment. The slot on striker must be kept

horizontal in order for door latch to catch

properly and latch.

4. Once proper slot alignment has been set, hold

striker close to its base then tighten the striker

nut. Be careful not to damage striker slot when

tightening or door may not latch properly.

NOTE: Do not over-tighten nut. If over-tightened,

striker may turn and change alignment.

NOTE: If door does not open easily, add shims

between striker and cabinet front. When adding

shims make certain that door gasket seals properly

and steamer does not leak. Remove shims as

necessary until leaking stops.

DRAIN BOX

WARNING: DISCONNECT THE ELECTRICAL POWER TO THE MACHINE AND FOLLOW

LOCKOUT / TAGOUT PROCEDURES.

REMOVAL AND REPLACEMENT

1. Turn off machine to drain steam generator tank.

Allow steamer to complete drain cycle.

A. Turn off water supply.

2. Disconnect the drain plumbing from drain box

outlet fitting.

3. Remove the RIGHT AND LEFT SIDE PANELS

as outlined in COVERS AND PANELS.

NOTE: Use plumbing sealant when reinstalling

condensate thermostat.

4. Disconnect the condensate thermostat electrical

wiring.

A. Remove the condensate thermostat from

drain box.

5. Disconnect the cooling solenoid and cooking

compartment drain hoses.

NOTE: The steam generator drain hose is accessed

from right side of machine.

6. Disconnect the steam generator drain hose.

7. Remove the nuts securing drain box to back

plate at rear of steamer.

8. Remove drain box from steamer.

9. Reassemble parts removed in reverse order.

10. Check steamer for proper operation and leaks

around condensate thermostat and hose

connection points.

1 2 ... 7 8 9 10 11 12 13 14 15 16 17 ... 51 52

Comments to this Manuals

No comments

Vulcan-hart C24EA3 480V BASIC User Manual Page 12

Comments to this Manuals